廣西中立源鍋爐廠家（咨詢熱線:158 7870 3621）生產供應生物質鍋爐、燃?xì)忮仩t等。產品無煙無塵，節能環保。今天廣西中立源鍋爐廠家為您介紹：蒸汽鍋爐的壓火操作步驟的問題，以下是小編對此問題的歸納整理，來看看吧。

1.蒸汽鍋爐的壓火操作步驟 (1)降低鍋爐負荷，根據停爐時間的長短，把煤層加厚，厚度一般不超過200毫米，適當加快爐排速度。 (2)加厚煤層至距離擋渣器1毫米左右，停止?fàn)t排轉動，停止鼓、引風機運作，關小分段送風的調節板擋和煙道擋板至適量，依靠自然通風維持煤的微弱燃燒，進行排污，將鍋爐水位上升到高允許水位。如果爐火燃盡煤閘板，可再次開動爐排，將燃煤往后移動一段距離。 (3)如鍋爐需要恢復運行，只要開啟引、鼓風機，調整煙、風擋板和分段風室調節擋板的開度，待蒸汽鍋爐燃燒正常時調整煤層厚度，開動爐排，即可恢復運行。 2.蒸汽鍋爐使用的注意事項 (1)開機前檢查電源、電壓、水源是否有異常情況，關閉排污閥開啟供水閥、檢查水泵是否卡死，若水泵卡死，拆下風葉后蓋，轉動電機軸至靈活狀態即可開機。 (2)當檢修蒸汽鍋爐或者更換配件時，請切斷電源以免帶電工作造成危險。 (3)電控箱、水泵電機等部位應避免受潮進水，以防燒毀，鍋爐應注意保持清潔。 (4)按照有關蒸汽鍋爐水質要求，在使用本設備時請務必安裝軟水器，因?yàn)椴皇褂密浰鲿斐慑仩t結垢，嚴重時會造成爆管，減短鍋爐壽命。 (5)在使用時請注意排污。每天至少排放一次并且?guī)?.1MPa到0.15MPa之間的壓力排放，可以防止管道堵塞，排污管應妥善連接，謹防燙傷。

中譯英： 1 Steam boiler pressure fire operation steps (1) To reduce boiler load, according to the shutdown time, the coal seam thickness of thick, generally not more than 200 mm, appropriate to speed up grate velocity. (2) Thick coal seam to distance slag stopper of about 1 mm, stop grate rotates, stop drum, induced draft fan operation, close small sectional air regulating plate retaining and flue baffle to right amount, rely on natural ventilation to maintain the weak coal combustion, pollution, the boiler water level rises to a maximum allowed level. If the fire burn coal gate, can actuate the grate coal again, moving back a short distance. (3) If the boiler need recovery operation, as long as the opening lead, blower, adjust the smoke, the wind baffle and zoned-air chambers regulating baffle opening, the steam boiler combustion adjustment of normal when the thickness of coal seam, to actuate the grate, to resume operation. 2 Matters needing attention in the use of steam boiler (1) Pre start checks power, voltage, water whether an abnormality, close the drain valve open the water supply valve, check the death card, if the water pump blocked, remove the wind blade cover, rotary motor shaft to the flexible state can boot. (2) When overhauling the steam boiler or replacement parts, please cut off the power supply to avoid dangerous live working. (3) Electronic control box, water pump motor parts should avoid dampness inlet, to prevent burning, boiler should pay attention to cleanliness. (4) According to the steam boiler water quality requirements, in the use of this equipment must be installed water softener, because do not use softener will cause the boiler scaling, serious when can cause detonation tube, shorten the service life of the boiler. (5) When in use, please pay attention to pollution. Every day at least emissions once and take 0.1MPa to 0.15MPa between pressure discharge, can prevent clogging the pipe, drain pipe should be properly connected, beware of scald.

以上就是小編對于蒸汽鍋爐的壓火操作步驟問題和相關問題的解答了，希望對你有用。中立源鍋爐生產廠家（熱線:158 7870 3621）專業銷售安裝：生物質蒸汽發生器,生物質鍋爐,蒸汽鍋爐,燃?xì)忮仩t,熱水鍋爐,蒸汽發生器,環保鍋爐,工業鍋爐,電蒸汽鍋爐,燃油鍋爐,生物質蒸汽鍋爐,天然氣鍋爐等.歡迎電話咨詢。